Tell us about the job
Takes about a minute. No obligation.
Sizing a furnace for a Lebanon County home is not a catalog exercise. 124 severe weather events were recorded in Lebanon County, Pennsylvania between 2015 and 2024. At that rate, severe weather is part of the normal working life of a heating system here, and a contractor who ignores it will undersize the equipment or miss the load the unit needs to carry through a hard winter. A licensed contractor will account for what this climate asks of the system before settling on capacity, not after.
Ductwork laid down for an older heating system carries assumptions about airflow, load, and layout that a modern furnace does not share. Half the homes in Lebanon County, Pennsylvania were built in 1972 or earlier (2020-2024 ACS 5-year). That spread across the county's housing stock means a contractor sizing a new furnace has to evaluate the existing duct runs before the equipment choice is settled, because undersized or misrouted ducts will choke a correctly sized unit just as surely as the wrong furnace would. The electrical service matters too, but ductwork is where installation scopes here tend to expand.
What Gets Installed With a New Furnace
The furnace itself sits in a basement, utility room, or mechanical closet and is the heart of what a contractor installs. Inside it, a burner assembly and a heat exchanger do the work of producing warm air, while a blower motor pushes that air out into the house. The flue pipe runs from the furnace to an exterior wall or the roof, carrying combustion gases out.
The air handler components work alongside the furnace and often share the same cabinet. A contractor also installs or connects the thermostat, which mounts on an interior wall and tells the furnace when to run. Where a home has an existing air conditioning coil, that evaporator coil sits directly above the furnace in the cabinet and ties into the same blower system.
The drawing shows a typical layout, and a licensed contractor determines what applies to your specific house and setup.
Find a contractor in Lebanon CountyLebanon County, by the numbers
124 severe weather events were recorded in Lebanon County, Pennsylvania between 2015 and 2024.
NOAA National Centers for Environmental Information, Storm Events Database, bulk CSV export, events 2015-01-01 through 2024-12-31.Half the homes in Lebanon County, Pennsylvania were built in 1972 or earlier (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesLebanon County, Pennsylvania holds 59,921 housing units (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesOwners occupy 71.3% of the occupied homes in Lebanon County, Pennsylvania (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesFurnace Installation Rules on the Books for Lebanon County, Pennsylvania7 sourced rules & standards
What the Install Actually Looks Like
Non-weatherized gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized oil-fired furnaces manufactured on or after November 19, 2015 must reach 83.0 percent AFUE.
Mobile home gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized gas furnaces manufactured on or after December 18, 2028 must reach 95.0 percent AFUE, up from the 80.0 percent minimum that applies to units manufactured before that date.
Licensing Rules for HVAC Work in Lebanon County, Pennsylvania
Pennsylvania names the trade in its own definition: installing central heating or air conditioning is a home improvement under the Act, whether or not the equipment is affixed — so an HVAC installation is work the registration requirement reaches.
A Pennsylvania registration displaces the local one: no political subdivision may require a home improvement contractor to register, license or pay a fee on top of it, though building permits and local code enforcement still apply.
Pennsylvania requires home improvement contractor registration rather than a licence: nobody may hold themselves out as a contractor, or perform any home improvement, without first registering with the Bureau of Consumer Protection.
Severe Weather Events in Lebanon County
Heating equipment in Lebanon County works against whatever the local climate brings, and the workload is shaped by how hard the weather swings. A furnace sized and installed for local conditions holds up better than one spec'd for somewhere else.
124 severe weather events, 2015–2024. Source: NOAA National Centers for Environmental Information, Storm Events Database.